Tech section strictly for the FJR. Everything from oil changes & suspension setup's to removing sheep hair from hard to reach places on the bike so that your wife never finds out.
RIP - JWilly - aka Jason - Memories and Tributes
Replies: 273
by
extrememarine »
Sat May 21, 2022 11:52 pm
» in
Notices
First post
Good evening.
Last post
I heartily approve of the route, the steak, and everything else. Good job Josh!
273 Replies
861689 Views
Last post by wheatonFJR
Wed Jun 11, 2025 6:44 pm
Where is the “Off Topic” area?
Replies: 19
by
extrememarine »
Fri Jan 18, 2013 9:47 pm
» in
Introductions
First post
Where is the “Off Topic” area?
Last post
Thank you - link updated!
19 Replies
116697 Views
Last post by extrememarine
Tue Aug 27, 2024 9:43 am
Oil Filter Gasket
Replies: 4
by
Italian Stallion »
Thu Jun 04, 2015 5:07 am
First post
I don't know if this has been mentioned here or not, and I apologize if it has, but on another forum that I frequent, this was posted, so I thought...
Last post
Bump an FJR off the center stand? Only if you bump it with a truck, hard. Lol...
4 Replies
2898 Views
Last post by Old Guy
Mon Jun 15, 2015 11:03 am
Brake Pads
Replies: 2
by
ts3doug »
Wed May 20, 2015 5:21 pm
First post
i trashed a fork seal and didn't catch it until the brake pads got screwed.
Last post
I found the number and ordered a couple of packages.
2 Replies
2262 Views
Last post by ts3doug
Thu May 21, 2015 8:03 am
throttle response issue
Replies: 18
by
dmshanks »
Mon Apr 27, 2015 12:29 am
First post
Greetings; I have a rough throttle response from 1000 to about 3000 rpm. Once the engine is at operating temp and I slowly roll the throttle from...
Last post
Nope. 2008 and up bikes were fixed of throttle issues. My '07 had never been bad. Kept it in check with properly adjusted throttle cables. Many...
18 Replies
7231 Views
Last post by HotRodZilla
Wed Apr 29, 2015 11:49 pm
Electrical issue
Replies: 27
by
fencer »
Sat Mar 14, 2015 4:19 pm
First post
The left hand control is all aflutter.
Last post
S6 It is.
27 Replies
9142 Views
Last post by SLK50
Sun Apr 05, 2015 6:08 pm
Gen 1 wind screen mods
Replies: 9
by
silverback »
Mon Jul 21, 2014 4:46 pm
First post
My wind screen, which I believe to be stock, doesn't allow enough air at my helmet in the low position and in the up position creates a leeward rotor...
Last post
I was looking at the mechanism yesterday and pondering the possibility of making some adjustments to the pick points to extend the range of the...
9 Replies
4335 Views
Last post by silverback
Mon Mar 23, 2015 11:56 am
Rough Idle/Dies - Gen II
Replies: 20
by
usaffjr »
Thu Oct 30, 2014 10:59 pm
First post
2006 FJR, ~23k miles, no engine mods, all recalls done (including wiring harness). I've owned it for the last 5 years/20k miles
Last post
Turns out the thermostat wasn't leaking, but a hose was... badly. Valves were in spec... Will post readings later. Dealer went through front to...
20 Replies
8365 Views
Last post by usaffjr
Sun Dec 21, 2014 6:53 pm
Valve Check Timing
Replies: 14
by
usaffjr »
Tue Nov 11, 2014 10:31 am
First post
With my bike not running right, the coolant leak at the thermostat housing, and 24k on the clock, I'm wondering if it would just be wise to let the...
Last post
Mine 09 needed a valve adj at 36k. I will leave the adjustment to the dealer but I don't mind doing the check. If you or the dealer do it depends on...
14 Replies
6617 Views
Last post by fontanaman
Sun Nov 30, 2014 12:18 am
Coolant Leak?
Replies: 16
by
0face »
Fri Nov 14, 2014 4:50 pm
First post
I've had this very small intermittent coolant leak. It would only leak if the engine was cold and I started it for a few seconds and then turned it...
Last post
Oh for fucks sakes you gawddam buncha gurlz!! Back when men carried our own balls ? We used to thicken milkshakes with mercury...
16 Replies
7222 Views
Last post by silverback
Sat Nov 22, 2014 5:01 pm
2014 Service Manual
Replies: 68
by
okeefjr »
Thu Jun 12, 2014 9:39 am
First post
Is there any place to look for 14 service manual other than Yamaha Stealership?
Last post
The copyright thingy we are talking is all a scam and doesn't really exist. You may do whatever you want! :o
68 Replies
27028 Views
Last post by beemerdons
Tue Sep 09, 2014 6:10 pm
Cruise Control and Short Term Electrical Sudden Death
Replies: 6
by
OldButNotDead »
Sun Aug 31, 2014 10:56 pm
First post
Hi guys, I posted the following on the FJRForum and I would like to get a fresh set of eyes on them.
Last post
After I reseated the CC fuse, which was not all the way in, I did not have a single problem today. Even hitting some pretty big bumps had no effect...
6 Replies
3231 Views
Last post by Geezer
Tue Sep 02, 2014 7:25 am
Mounting T30GT's by hand?
Replies: 12
by
Mattthehoople »
Sun Jul 13, 2014 4:04 pm
First post
So guys,
Last post
You know what? I didn't really investigate the MojoLever. I just purchased some tire spoons at Northern Equipment.
12 Replies
5973 Views
Last post by Mattthehoople
Fri Jul 18, 2014 12:58 pm
Gen III TBS
Replies: 2
by
bungie4 »
Sat Jul 05, 2014 6:24 pm
First post
Holy sweet merciful shit is that a pain in the ass.
Last post
Little tip: I marked the location of the adjustment screws on the fuel rail using a sharpie. Makes finding them much easier with the tank propped...
2 Replies
2492 Views
Last post by bungie4
Sun Jul 06, 2014 8:17 am
Fork Seals
Replies: 21
by
usaffjr »
Wed Apr 16, 2014 6:47 pm
First post
So my right fork is leaking fluid. Fairly significant amount judging by how quickly the fork tube was converted in gunk. My Google-foo has shown...
Last post
I had them replaced. Didn't want to risk messing it up right before the road trip... :-(
21 Replies
10236 Views
Last post by usaffjr
Thu Jun 12, 2014 12:02 am
Ingenuity is a mother, but cool.
Replies: 1
by
bungie4 »
Thu Jun 05, 2014 3:22 pm
First post
Remove and install a tire using only zip ties.
Last post
I've tried mounting a front tire for my ZRX like this, and it did not work out so well. :(
1 Replies
2327 Views
Last post by Old Guy
Thu Jun 05, 2014 9:08 pm
Pressing in new wheel bearings.
Replies: 18
by
puppychow »
Thu May 29, 2014 5:01 pm
First post
It seems a pretty simple task that I could do myself, or I think so looking at DIY videos online. However, I have never done this before myself and...
Last post
Thanks. I will check them the next time I take the tires off.
18 Replies
7162 Views
Last post by Intech
Tue Jun 03, 2014 7:00 am
Front Wheel Bearings
Replies: 16
by
Name Etc. »
Thu Nov 07, 2013 11:17 am
First post
I decided to Change my front wheel bearings just for drill. My 2007 A model has 86,000 and change on it. I have ridden 9000 mile tours. Weeks...
Last post
Great info! Thanks!! I think I will go the freeze and heat route, but at my friend's place. Throw the bearings in the freezer, take out a couple of...
16 Replies
7833 Views
Last post by puppychow
Mon Jun 02, 2014 4:55 pm
Dark side
Replies: 26
by
okeefjr »
Sat May 10, 2014 11:28 pm
First post
I ran car tires on my wings for a long time and just wanted to inquire about possibilities on the FJR. Is there a special section on this forum for...
Last post
quoted from ADVRiders:
26 Replies
10752 Views
Last post by wpbfjr
Mon May 26, 2014 2:18 pm
Hard bag hanging
Replies: 8
by
PhilJet09 »
Sun Apr 13, 2014 3:19 pm
First post
I only seem to use my side cases for traveling as my top case is better suited for daily commuting, so I needed a place to store them where they...
Last post
slick...now i just need a garage...
8 Replies
4485 Views
Last post by PhilJet09
Thu May 22, 2014 7:46 am
Lowering the bike
Replies: 11
by
okeefjr »
Wed May 14, 2014 7:40 pm
First post
With my head down in shame--- I dropped my new bike scratching the left mirror, left side cover and saddlebag. With my 29 inseam I'm having a really...
Last post
Why keep changing the world around you every time you get something new or meet a new challenge? Address the shortcoming once and be done with it...
11 Replies
6684 Views
Last post by HotRodZilla
Thu May 15, 2014 6:40 pm
Anyone swapped over to a lithium battery?
Replies: 20
by
fencer »
Tue Apr 08, 2014 12:53 am
First post
What did you get and how is that working out?
Last post
If these things have this major problem of having little to no power when cold, does anyone know if electric cars with similar batteries suffer the...
20 Replies
10092 Views
Last post by MrZappo
Wed Apr 09, 2014 3:31 pm
front end troubleshooting
Replies: 1
by
wpbfjr »
Tue Apr 01, 2014 11:28 am
First post
hi, need help on troubleshooting a fork issue.
Last post
I've had a Klunk in the forks when hitting expansion joints / pot holes. It ended up being a loose top clamp. Don't see how that's tied to your tire...
1 Replies
2368 Views
Last post by extrememarine
Tue Apr 01, 2014 11:38 am
Fork Oil Change
Replies: 11
by
0face »
Sun Mar 30, 2014 3:17 pm
First post
Anybody want to post a How To? I'm about to embark on this.
Last post
Sweet. This is just the info I'm looking for. Thanks!
11 Replies
5998 Views
Last post by 0face
Mon Mar 31, 2014 10:17 am
Airbox Removal
Replies: 31
by
Name Etc. »
Thu Oct 31, 2013 12:05 pm
First post
who has removed the air box? how hard is it? Been running a K and N and recently found evidence that it is oil gumming up the Throttle body Assy....
Last post
I think the slow change in how the bike runs snuck up on me. Man she is smooth.... Hasn't felt like this in years I just forgot.
31 Replies
12560 Views
Last post by Name Etc.
Sun Nov 17, 2013 10:20 am
Spark Plug Gapping
Replies: 20
by
0face »
Wed Oct 23, 2013 1:38 pm
First post
I just did a spark plug change on my car. I had to gap all the plugs as they didn't come with the recommended gap. It got me thinking, what is the...
Last post
The length of the porcelain will determine the temperature of the spark plug. The port velocity, swirl of the combustion chamber, compression, target...
20 Replies
10949 Views
Last post by ionbeam
Mon Oct 28, 2013 1:38 pm
TBS modification
Replies: 21
by
Intech »
Mon Oct 14, 2013 10:04 am
First post
I installed this homemade manifold to make performing a TBS much easier. It is aircraft grade tubing. It has held up for almost three years with no...
Last post
Can you explain how the length of tube will change the pressure?
21 Replies
11531 Views
Last post by Bust
Thu Oct 17, 2013 10:37 am
Forum permissions
You cannot post new topics in this forumcannot reply to topics in this forumcannot edit your posts in this forumcannot delete your posts in this forum
